From: AdaCONWIN@aol.com Date: Thu, 17 Feb 2000 13:03:37 EST Subject: Tune-up for Conwin's Dual Sizer and Duplicator 2 To: balloondeco@balloonhq.com Now that Valentine's Day is over and IBAC is just around the corner, this is a good time to give your <A HREF="http://www.conwinonline.com/product.asp?pcode=BI3">Dual Split-Second Sizer</A> or <A HREF="http://www.conwinonline.com/product.asp?pcode=BI3">Dupli cator 2</A> a Seven Point Tune-Up. Here's step-by-step instructions on how to lubricate your inflator. Be sure to wear eye protection for this procedure. 1. Set your inflator to 9.0 seconds at 90 PSI. Tap the foot pedal or press the inflation button 3 times to cycle the unit. This will blow out any foreign particles that may have entered the system. 2. Remove the filling outlets and gas supply line from unit. 3. Spray silicone lubricant into gas supply port (located in the back of the unit) and into the latex inflating port(s) on the top of the unit. IMPORTANT: Only use spray silicone lubricant. Do Not lubricate the unit with an oil based lubricant. Spray silicone lubricant is available at your local automotive or hardware store. 4. Tilt the inflator to the right and hold for a few seconds then tilt the inflator to the left and hold for a few seconds. This will allow the silicone lubricant to fully enter the unit. 5. Attach the gas supply line and pressurize the unit. Do not attach filling outlets. 6. Set your unit to 0.3 seconds at 80 PSI. Cover the inflating ports on the top of the unit with a rag and tap the foot pedal or press the inflation button 10 times to fully lubricate the unit. 7. Before using you inflator it is important to blow out all the excessive silicone lubricant. Place a clean paper towel over the outlets and tap the foot pedal or press inflation button to cycle the unit. If the towel shows any signs of the lubricant it is necessary to continue cycling the unit. When the towel shows no signs of lubricant replace filling outlets. Now your inflator is now ready to inflate balloons. Ada Olivera, Regional Sales Manager <A HREF="http://www.conwinonline.com/H1.asp">ConwinOnline </A> Don't forget: There are only 14 days left to enter <A HREF="http://www.conwinonline.com/FZ2.asp">Conwin Contest</A>. You could be the lucky winner!